Ford Archives - Page 3 of 4 - Caliber Auto Repair

2011 Ford Pickup
Mileage
118,473
Service Date
8/12/2022
Services Performed
DIAGNOSED AND REPLACED RIGHT REAR DOOR HARNESS
REMOVE FRONT BUMP STOPS TO GET SENT OUT TO BE REBUILT
REMOVE AND INSTALL FRONT BUMP STOPS FOR REBUILD
REPAIR AND PAINT LEFT REAR CORNER OF BED AND REAR BUMPER, PAINT AND BLEND DRIVERS DOOR, PAINT ROOF, PAINT FENDER FLAIRS.
DETAIL
CODY M. gave our service a 5 star review on 8/13/2022
2006 Ford Pickup
Mileage
148,038
Service Date
8/5/2022
Services Performed
CUSTOMER SAYS REAR OF VEHICLE FEELS LIKE IT IS LOCKING UP AND HOPPING AROUND. CHECK AND ADVISE
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
fuel
TOM H. gave our service a 5 star review on 8/5/2022
2006 Ford Pickup
Mileage
150,148
Service Date
4/28/2022
Services Performed
HAZARDOUS WASTE DISPOSAL (OIL AND FILTER)
Lubricated and checked chassis. Changed oil and oil filter. Checked air filter and breather filter. Checked all fluid levels and tire pressures. Performed basic safety inspection. Road tested vehicle.
Inspected front brakes pads & rotors as well as rear brake pads and rotors or shoes and drums for brake condition & measurements. Inspected entire system for leaks. Lining remaining is: Front (6MM) Rear (NEW)
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
DUPLICATED ISSUE ONCE ON TEST DRIVE. BLINKERS DID NOT ACT UP WHILE AT THE SHOP.
GOT LEFT REAR DOOR OPEN. REMOVED PANEL TO ACCESS AND INSPECT. FOUND REAR DOOR LATCH ASSEMBLY CABLES ARE BAD. TWO CABLES ARE APART OF DOOR LATCH ASSEMBLY. RECOMMEND REPLACING LEFT REAR DOOR LATCH ASSEMBLY -LEFT REAR DOOR LATCH/CABLE ASSEMBLY – REMOVED & REPLACED
REMOVED DOOR PANEL. FOUND LOOSE BOLTS IN BOTTOM OF THE DOOR. FOUND WINDOW NOT CONNECTED TO THE WINDOW REGULATOR. FOUND WINDOW STUCK IN UP POSITION DUE TO WINDOW VISOR. REMOVED WINDOW VISOR TO GET WINDOW DOWN. VERIFIED MOTOR WORKS. RECONNECTED WINDOW TO WINDOW REGULATOR. WINDOW ROLLS UP AND DOWN AS IT SHOULD. WINDOW DOES NOT WORK FROM PASSENGER SIDE, NEEDS PASSENGER SIDE WINDOW SWITCH TO WORK FROM PASSENGER DOOR. CUSTOMER DECLINED PASSENGER WINDOW SWITCH AT THIS TIME.
QUOTED CUSTOMER ON TIRES
DID NOT DUPLICATE SHOCKS SQUEAKING. DID FIND FRONT SWAY BAR END LINK BUSHINGS HAVE DISINTEGRATED AND ARE MISSING. RECOMMEND REPLACING BOTH FRONT SWAY BAR END LINKS. -FRONT SWAY BAR END LINKS – REMOVED & REPLACED
FUEL TANK FILLER PIPE HOUSING – Removed & Replaced – F150
-Replace rear brake pads and replace rear brake rotors. Clean and lubricate brake calipers and slide mechanisms. Road test vehicle.
Check for driveshaft clunk. Verified concern. Drive shaft slip yoke boot clamps missing. Ford makes a driveshaft lube kit with new clamps for this issue. -Performed driveshaft lube on slip yolk. Also found driveshaft clocked wrong. Clocked driveshaft correctly
REPLACED T AND UNCLOGGED LINE AND WIPERS WORK NOW.
TIM S. gave our service a 5 star review on 4/28/2022
2008 Ford Pickup
Mileage
179,303
Service Date
3/29/2022
Services Performed
-DRIVE BELT – Removed & Replaced – F150,V8 – [Includes: Serpentine and V-Belt type Belt(s).]
Hooked up BG Brake fluid machine to brake fluid reservoir. Performed brake fluid exchange using BG DOT 4 brake fluid. Verified condition of brake fluid once service is performed. Verified braking system has no air in system.
HAZARDOUS WASTE
SUSAN S. gave our service a 5 star review on 3/30/2022
2007 Ford Mustang
Mileage
130,630
Service Date
3/16/2022
Services Performed
CUSTOMER SAYS VEHICLE HAS RATTLES, INSPECT AND ADVISE ON REPAIRS
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
-ON INSPECTION FOUND BOTH FRONT LOWER CONTROL ARMS BUSHINGS WITH SEVERE PLAY AND BALL JOINTS WITH SEVERE PLAY. ALSO FOUND BOTH INNER TIE ROD ENDS WITH SEVERE PLAY. RECOMMEND REPLACING BOTH FRONT BOTH CONTROL ARMS AND BOTH INNER TIE ROD ENDS -LEFT & RIGHT FRONT LOWER CONTROL ARMS – Removed & Replaced – Lower,Both – [DOES NOT include alignment.] -INNER TIE RODE ENDS – LEFT & RIGHT
PERFORMED FRONT WHEEL ALIGNMENT. ADJUST TO FACTORY SPECIFICATIONS. TEST DROVE VEHICLE TO VERIFY ALIGNMENT.
-TRANSMISSION OIL PAN FILTER – Removed transmission pan, removed and replaced transmission filter. Transmission pan did have metal on magnetic. Reinstalled transmission pan. Added new fluid with BG transmission conditioner
HAZARDOUS WASTE DISPOSAL (TRANSMISSION FLUID)
RESTORE HEADLIGHTS
-OIL PRESSURE SENDER SWITCH – Removed & Replaced
KIM O. gave our service a 5 star review on 3/17/2022
2007 Ford Escape
Mileage
103,724
Service Date
2/4/2022
Services Performed
PERFORMED FUEL INDUCTION SERVICE WITH 3 PART BG ENGINE DECARBON KIT. CLEANED THROTTLE BODY & MASS AIR FLOW METER. PERFORMED THROTTLE RELEARN, IF APPLICABLE.
Hooked up BG Brake fluid machine to brake fluid reservoir. Performed brake fluid exchange using BG DOT 4 brake fluid. Verified condition of brake fluid once service is performed. Verified braking system has no air in system.
HAZARDOUS WASTE
SOFTWARE UPDATE
ASH D. gave our service a 5 star review on 2/4/2022
2005 Ford Pickup
Mileage
176,967
Service Date
1/27/2022
Services Performed
Check engine light on. Found Code p0430 cat efficiency bank 2 below threshold. Checked spark plugs, small misfires known to set catalytic codes and damage catalytic converter. Found plugs to be extremely worn and aftermarket. Recommend replacing spark plug -SPARK PLUGS – REMOVED & REPLACED -CATALYTIC CONVERTER CODE MAY RETURN IF CATALYTIC CONVERTER IS NO OPERATING EFFICIENTLY BUT SPARK PLUGS HAD TO BE REPLACED FIRST. iF P0430 CODE RETURNS, WILL NEED DIAGNOSTICS. -WHILE REPLACING SPARK PLUGS, FOUND PCV HOSE BROKEN IN HALF UNDER FOAM SHEAVING. RECOMMEND REPLACING PCV HOSE.
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
PERFORMED FUEL INDUCTION SERVICE WITH 3 PART BG ENGINE DECARBON KIT. CLEANED THROTTLE BODY & MASS AIR FLOW METER. PERFORMED THROTTLE RELEARN, IF APPLICABLE.
-TRANSMISSION OIL PAN & GASKET – Removed & Replaced – F150 -Removed transmission oil pan, replaced transmission filter and transmission oil pan gasket. Reinstalled transmission pan. Added new fluid.
HAZARDOUS WASTE DISPOSAL (TRANSMISSION FLUID)
-LEFT LOWER BALL JOINT – Removed & Replaced – F150,RWD Lower,One Side,w/Steering Knuckle Removal – [DOES NOT include alignment.] -RECOMMEND ALIGNMENT AFTER BALL JOINT REPLACEMENT
PERFORMED FRONT WHEEL ALIGNMENT. ADJUST TO FACTORY SPECIFICATIONS. TEST DROVE VEHICLE TO VERIFY ALIGNMENT.
LANE S. gave our service a 5 star review on 1/27/2022
2007 Ford Mustang
Mileage
127,976
Service Date
11/8/2021
Services Performed
Check engine light on. Verified complaint. Scanned faults P0108 and P0406. See print out. Verified powers and grounds good. Reference voltage correct. Found failure of EGR Valve assembly. Need to replace and retest. -EGR VALVE ASSEMBLY – REMOVED & REPLACED
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
Hooked up BG Brake fluid machine to brake fluid reservoir. Performed brake fluid exchange using BG DOT 4 brake fluid. Verified condition of brake fluid once service is performed. Verified braking system has no air in system.
HAZARDOUS WASTE
Aired up all tire pressures and light shut off. Pressures were too low at 26psi
KIM O. gave our service a 5 star review on 11/9/2021
2004 Ford Excursion
Mileage
204,152
Service Date
11/5/2021
Services Performed
Inspected front brakes pads & rotors as well as rear brake pads and rotors or shoes and drums for brake condition & measurements. Inspected entire system for leaks. Lining remaining is: Front (10MM) Rear (10MM)
Lubricated and checked chassis. Changed oil and oil filter. Checked air filter and breather filter. Checked all fluid levels and tire pressures. Performed basic safety inspection. Road tested vehicle.
HAZARDOUS WASTER DISPOSAL (OIL & FILTER)
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
PERFORMED TIRE ROTATION & AIRED TIRES UP TO PROPER AIR SPECIFICATION
BOB L. gave our service a 5 star review on 11/5/2021
2009 Ford Focus
Mileage
139,438
Service Date
11/3/2021
Services Performed
NEEDS RIGHT MOUNT AND TORQUE MOUNT
BRAKE MEASUREMENTS LOOKS GOOD.
HAZARDOUS WASTE DISPOSAL (OIL AND FILTER)
Lubricated and checked chassis. Changed oil and oil filter. Checked air filter and breather filter. Checked all fluid levels and tire pressures. Performed basic safety inspection. Road tested vehicle.
Inspected front brakes pads & rotors as well as rear brake pads and rotors or shoes and drums for brake condition & measurements. Inspected entire system for leaks. Lining remaining is: Front (7MM) Rear ( MM)
FULL DIGITAL INSPECTION
FLOOR MAT & SEAT COVER IN CUSTOMER VEHICLE
INSPECT & CLEAN ANY GREASE MARKS AND FINGER PRINTS FROM INSIDE AND OUTSIDE OF CUSTOMERS VEHICLE WHEN DONE WITH REPAIRS
RESET SERVICE LIGHT IF PERFORMING OIL CHANGE
WHEEL LOCK KEY LOCATION_________________________________
DAVID T. gave our service a 5 star review on 11/3/2021

Ford

We Service and Repair all Ford cars